Product ID:POXIPATCH, 4022
MSDS Date:05/06/1992
FSC:8030
NIIN:00N055798
MSDS Number: BWDJZ

MANTEK DIV OF NCH CORP

IRVING, TX 75015
US

Emergency Phone: 214-438-1381

Info Phone: 214-438-1381

Preparer: K RAHN

Cage: GO368

NCH CORP

152170 IRVING, TX 75015-2170 US

Telephone: 972-438-0563

Cage: 20913

PROPANE,2,2-BIS(P-(2,3-EPOXYPROPOXY)PHENYL)-; (ALIPHATIC

CAS: 1675-54-3

RTECS: TX3800000

OSHA PEL N/K

ACGIH TLV: N/K

(ORAL,RAT)

CAS: 111-40-0

RTECS: IE1225000

OSHA PEL 1 PPM

ACGIH TLV: 1 PPM, S

SILICA, CRYSTALLINE - QUARTZ;(SILICONE DIOXIDE). POWDER

CAS: 14808-60-7

RTECS: VV7330000

OSHA PEL 10 MG/M3 RDUST; Z-3

ACGIH TLV: 0.1 MG/M3 RDUST

INHAL OF SILICON DIOXIDE CAN CAUSE A PROGRESSIVE

RTECS: 9999999ZZ

THAT PERSONS DIAGNOSED WITH SILICOSIS HAVE AN

RTECS: 9999999ZZ

LAUNDER CONTAMD CLTHG BEFORE REUSE. APPLY

RTECS: 9999999ZZ

KEEP PERS WARM, QUIET & GET MED ATTN. ASPIR OF MATL

RTECS: 9999999ZZ

GASTRIC LAVAGE IS INDICATED.

RTECS: 9999999ZZ

DUST GENERATED DURING THE MIXING OF THE PRODUCT.

RTECS: 9999999ZZ

ANTICIPATED TO BE

RTECS: 9999999ZZ

LD50 LC50 Mixture:SEE INGREDIENT 2
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: PART A: UPON EYE CONT, PROD MAY
CAUSE MOD IRRIT & REVERSIBLE CORNEAL DMG. UPON SKIN CONT, PROD MAY
CAUSE MOD SKIN IRRIT & POSS ALLERGIC REPONSE. UPON INHAL, PROD MAY
CAUSE POSS RESP IRRIT. MATL ASPIR INTO LUNGS MAY CAUSE CHEM
PNEUM.UPON INGEST, PROD MAY CAUSE NAUS, ABDOM PAIN & POSS
COLLAPSE.(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPPLEMENT. VOL 7, PG 341, 1987: GROUP 2A. NTP 7TH
ANNUAL REPORT ON (ING 10)
Effects of Overexposure:HLTH HAZ: PART B: EYE CONT: PROD IS CORROSIVE &
MAY CAUSE SEV IRRIT & CHEM BURNS W/PERM EYE INJURY & EVEN
BLINDNESS. SKIN: PROD IS CORR & MAY CAUSE SEVERE IRRIT, CHEM BURNS
& BLISTERS. PROD MAY BE ABS ORBED THROUGH SKIN IN HARMFUL AMTS.
INHAL: PROD MAY CAUSE IRRIT OF RESP TRACT, HDCH, NAUS & VOMIT.
PROD ASPIR (SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING PULMONARY &
DERMATOLOGICAL DISORDERS MAY BE AGGRAVATED BY EXPOSURE.

First Aid:INHAL: GET PERS OUT OF CONTAMD AREA TO FRESH AIR. IF BRTHG
HAS STOPPED, ARTF RESP SHOULD BE STARTED. O*2 MAY BE ADMIN, IF
READILY AVAIL. SEEK MED ATTN IMMED. EYE: FLUSH W/LGE AMTS OF WATER
FOR AT LEAS T 15 MINS, LIFTING UPPER & LOWER LIDS OCCAS. GET MED
ATTN IF IRRIT PERSISTS. TREATMENT IS MOST EFTIVE W/IN ONE MINUTE.
SKIN: THORO WASH EXPOSED AREA W/SOAP & WATER. REMOVE CONTAMD CLTHG.
(ING 6)

Flash Point Method:TCC
Flash Point:215F,102C
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT. PRODUCT IS NON-FLAMMABLE.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. USE ABSORBANT
SUCH AS PAPER, VERMICULITE, ETC. TO CONTAIN SPILL. DO NOT FLUSH TO
SEWER. PLACE INTO LABELED CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AT MODERATE TEMPERATURES(32F -
120F). AVOID CONTACT W/SKIN.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. READ ENTIRE LABEL
BEFORE USING PRODUCT.

Respiratory Protection:TYPICAL USAGE OF PROD DOES NOT REQ USE OF A
RESP. HOWEVER, IN AN EMER SITUATION, USE NIOSH/MSHA APPRVD ORGANIC
VAP/AIR-LINE RESPS. USE A SCBA IN CONFINED SPACES IN EMER
SITUATIONS. USE OF DUST MASK MA Y BE REQD TO AVOID INHAL OF (ING 9)
Ventilation:LOCAL EXHAUST RECOMMENDED TO KEEP AIR CONCENTRATION WELL
BELOW ESTABLISHED TLV.
Protective Gloves:IMPERVIOUS NEOPRENE GLOVES.
Eye Protection:CHEMICAL SPLASH GOGGLES.
Other Protective Equipment:RUBBER APRON DEPENDING ON SEVERITY OF
EXPOSURE. EYE WASH FOUNTAIN & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP: INTO LUNGS MAY CAUSE CHEM PNEUM. INGEST: PROD MAY
CAUSE IRRIT/BURNS OF MOUTH, THROAT & STOMACH. SYMPS MAY INCL NAUS,
ABDOM PAIN & EVEN COLLAPSE. CHRONIC: SKIN: CAN LEAD TO TISS DESTRU
CTION & CAN CAUSE SENSITIZATION & CONT DERM. INHAL:CAN LEAD TO
ALLERGENIC RESPONSES INCLDG ASTHMATIC TYPE CNDTN.(ING 4)

Boiling Pt:B.P. Text:390F,199C
Vapor Pres:4
Vapor Density:>10
pH:10
Evaporation Rate & Reference:<0.10 (BUAC=1)
Solubility in Water:NEGLIGIBLE.
Appearance and Odor:OPAQUE GREY-GREEN W/LOW TO NO ODOR.
Percent Volatiles by Volume:2

Stability Indicator/Materials to Avoid:YES
ACIDS & OTHER EPOXY RESINS.
Stability Condition to Avoid:MIXTURE OF PART A & B WILL HARDEN &
GENERATE HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE & OXIDES OF NITROGEN.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.